簡易檢索 / 詳目顯示
| 研究生： |
胡念英 Nien-ying Hu |
|---|---|
| 論文名稱： |
污水處理廠沉澱池操控用SS沉澱特性自動量測裝置之發展與應用 Application of an Automatic Monitoring Suspended Settling Characteristic Instrument for Sedimentation Tank of wastewater Treatment Plant |
| 指導教授： |
廖述良
Shu-liang Liaw |
| 口試委員: | |
| 學位類別： |
碩士 Master |
| 系所名稱： |
工學院 - 環境工程研究所 Graduate Institute of Environmental Engineering |
| 畢業學年度： | 96 |
| 語文別： | 中文 |
| 論文頁數： | 103 |
| 中文關鍵詞： | SS 、自動監測 、廢水操控 、沉澱池 、沉澱特性 |
| 外文關鍵詞： | Sedimentation tank, SS, Auto-monitor, Operation of waste water, Settling characteristic |
| 相關次數： | 點閱：14 下載：0 |
| 分享至: |
| 查詢本校圖書館目錄 查詢臺灣博碩士論文知識加值系統 勘誤回報 |
一般污水處理廠沉澱池之操作控制，須藉由實驗室採樣分析取得水質資訊或以污泥濃度計作為沉澱池排泥之操作控制參考，無法就整體沉澱池操作控制上提供一即時資訊。本研究係利用以Beer-Lambert原理基礎所發展之水中量測SS沉澱特性之技術與裝置，於新竹工業區污水處理廠沉澱池進行水質SS連續量測與控制應用。本研究結果顯示SS自動量測系統可提供即時水質SS沉降變化之資訊且有效推估掌握出水水質變化趨勢，並可提供如累積沉澱質量分布及沉澱速度、停留時間與出水水質之關係等即時資訊，做為沉澱池與前置處理單元程序調整之控制，以提升廢水處理容量、效益與操作系統穩定性。目前一般市售之監測設備而言，大多僅能量測單元內單點水質之濃度，而本系統可利用於分析計算得知沉澱時不同水深SS濃度變化情形、沉澱過程中沉澱SS隨深度之累積質量分佈及沉澱速度等資訊，並由量測結果推估出流水SS濃度之功能。本監測系統設備設置及操作維護成本較市售儀器便宜，且具有可獲得多種資訊、提供操作控制即時資訊等優點，故可提升市場接受度及使用率，並有助於污水廠之操作與污染控制。
In generally, the operation reference for Sedimentation tank in waste water treatment plant, especially for sludge effluent, is controlled by results of laboratory analysis or sludge concentration meter, but is not controlled by on line data research.
The purpose of this research is to develop a technology and device for SS settling characteristic measurement, and is proved and continuously monitored the SS in sedimentation tank in Hsin-Tsu Industrial wastewater treatment plant, based on Beer-Lambert theory. The results of this research, shown SS automatic measurement system, not only offer the on line data of SS settling change, and effectively estimate the change trend of effluent waster water quality, but also offered the output on line information, such as average specific gravity, integrated settling weight distribution, settling velocity, retention time and effluent waste water… etc., is on purpose to adjust the process of sedimentation tank and pretreatment units, in order to upgrade the treatment capacity efficiency and system steady.
At this stage, most monitor equipments in market just could measure the one spot concentration of waste water quality. But we could get the variation of SS concentration at different depth, SS integrated weight distribution with the depth and settling velocity by means of results of calculation and Analysis. Moreover we could estimate the SS concentration of effluent by the results of this measurement. The capital and O&M cost of our system are cheaper than the existing equipments in market, and are beneficial to get more information and controlled by on line data. Therefore, the system is not only populous and acceptance for end users, but also is helpful for operation and pollution control in waste water treatment plant.
1. Bye, C. M. and Dold, P. L., “Sludge Volume Index Settleability Measure: Effect of Soilds Characteristic and Test Parameters”, Water Environmental Research, v.70, pp.87-93, 1998.
2. Diagger, G. T. and Roper, R. E., “The Relationship Between SVI and Activated Sludge Settling Characteristics”, Journal Water Pollution Control Federation, v.57, pp.859-866, 1985.
3. Eckenfelder, W. W. and Grau, P., “Activated Sludge Process Design and Control: Theory and Practice”, Technomic Publishing Company, Inc., 1992.
4. George Stephanopoulos, “Chemical Process Control- An Introduction to Theory and Practice”, Prentice Hall, Inc., 1987.
5. Grijspeerdt, K. and Verstraete, W., “A Sensor for the Secondary Clarifier Based on Image Analysis”, Water Science and Technology, v.33, pp.61-70, 1996.
6. Grijspeerdt, K. and Verstraete, W., “Image Analysis to Estimate the Settleability and Concentration of Activated Sludge”, Water Research, v.31, pp.1126-1134, 1997.
7. Hopkin, L. , “The Settling Stage, Internal Report, Advanced Wastewater Research Centre”, The University of Queenslan., 1997.
8. Rasmussen, M. R. and Larsen, T., “On-line Measurements of Settling Characteristics in Activated Sludge”, Water Science and Technology, v.36, pp.307-312, 1997.
9. Sekine, T., Tsugura, H., Urushibara, S., Furuya, N., Fujimoto, E., and Matsui, S. “Evaluation of settleability of activated sludge using a sludge settling analyzer”, Water Research, v.23, pp.361-367, 1989.
10. Skrentner, R. G. , “Instrumentation Handbook for Water ＆ Wastewater Treatment Plants”, Lewis Publishers, 1990.
11. Vanderhasselt, A. and Vanrolleghem, P. A., “Estimation of Sludge Sedimentation Parameters From Single Batch Settling Curves”, Water Research, v.34, pp.395-406, 2000.
12. Vanrolleghem, P., Van der Schueren, D., Krikilion, G., Grijspeerdt, K., Willems, P., and Verstraete, W., “On-line Quantification of Settling Properties with In-Sensor-Experiments in an Automated Settlometer”, Water Science and Technology, v.33, pp.37-51, 1996.
13. Tom D. Reynolds 著，李孫榮、張錦松、張錦輝、陳健民、曾如娟 共譯， 「環工單元操作」，高立圖書，1996.
14. 高肇藩，给水工程，1990.
15. 楊萬發，廢水處理單元設計及操作準則之試驗建立，1992.
16. 歐陽嶠暉、吳明洋，「動態活性污泥系統自動操作控制初期研究」，第十六屆廢水處理研討會專題報告，pp.15-26, 1991.
17. 萬騰州，「污水處理廠最佳化設計之研究（第三次論文報告資料）」，1989.
18. 陳信豪，「應用廢水水質自動監測系統於污水處理廠操控之研究」，國立中央大學環境工程研究所碩士論文，2007.
19. 鄭禹祥，「COD、SS及流量即時自動監測系統之發展與建立」，國立中央大學環境工程研究所碩士論文，2007.
20. 王祥洲，「廢水處理系統光學監測系統之發展－非接觸式廢水流量與色度監測技術之建立」，國立中央大學環境工程研究所碩士論文，2004.
21. 孫政遠，「連續流循序批分式活性污泥系統自動控制策略發展與系統建置—線上污泥沉降性監測方法之建立」，國立中央大學環境工程研究所碩士論文，2004.
22. 蔡傑寧，「以量筒沉降試驗評估載體混凝技術之可行性」，朝陽科技大學環境工程與管理研究所碩士論文，1994.
23. 林金德,曾迪華，「連續迴流污泥操作對重金屬廢水化學沉降處理產生污泥性質影響之研究」，中華民國環境工程學會第十六屆廢水處理技術研討會論文集，1991.
24. 余永成，「污水處理系統監測設備及維護」，環保工程科技-下水道工程研討會，1991.
